Kia Cee'd: Front Seat Belt / Front Seat Belt Pretensioner Repair procedures

Kia Cee'd JD Service Manual / Body (Interior and Exterior) / Front Seat Belt / Front Seat Belt Pretensioner Repair procedures

Replacement
[5Door, Waggon]
  
When installing the belt, make sure not to damage the pretensioner.
1.
Remove the center pillar upper trim.
(Refer to Interior Trim - "Center Pillar Trim")
2.
After loosening the mounting bolt, then remove the front seat belt upper anchor (A).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.8 ~ 39.8 lb-ft)

3.
After disconnecting the pretensioner connector lock pin, remove the front seat belt pretensioner connector (B), loosen the mounting bolts, then remove the front seat belt pretensioner (A).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.8 ~ 39.8 lb-ft)

4.
Install in the reverse order of removal.
  
Replace any damaged clips.
Make sure the connector is plugged in properly.
[3Door]
  
When installing the belt, make sure not to damage the pretensioner.
1.
Remove the rear inner outer trim.
(Refer to Interior Trim - "Center Pillar Trim")
2.
After loosening the mounting bolt, then remove the front seat belt lower anchor (A).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.8 ~ 39.8 lb-ft)

3.
Remove the front seat belt upper anchor cover (A).

4.
After loosening the mounting bolt, then remove the front seat belt upper anchor (A).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

5.
After disconnecting the pretensioner connector lock pin, remove the front seat belt pretensioner connector (B), loosen the mounting bolts, then remove the front seat belt pretensioner (A).
Tightening torque :
39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.8 ~ 39.8 lb-ft)

6.
Install in the reverse order of removal.
  
Replace any damaged clips.
Make sure the connector is plugged in properly.
Front Seat Belt Pretensioner Components and components location
Component Location [5Door, Waggon]   1. Front seat belt pretensioner [3Door]   1. Front seat belt ...

Height Adjust Components and components location
Component Location [5Door, Waggon only]   1. Height adjust ...

Other information:

Kia Cee'd JD Owners Manual: Necessary inspections
Fluid levels, such as engine oil, engine coolant, brake fluid, and washer fluid should be checked on a regular basis, with the exact interval depending on the fluid. Further details are provided in chapter 7, “Maintenance”. WARNING Driving while distracted can result in a loss of v ...

Kia Cee'd JD Owners Manual: Manual transaxle operation
■ Type A ■ Type B The manual transaxle has 6 forward gears. This shift pattern is imprinted on the shift knob. The transaxle is fully synchronized in all forward gears so shifting to either a higher or a lower gear is easily accomplished. Depress the clutch pedal down ...

© 2017-2022 www.kceed.com